Roll the floor jack out from under the Expedition and then reconnect the negative battery cable to the battery. Reconnect the fuel pump wiring harness, fuel lines and fuel filler neck before raising the tank to the full height.īolt the gas tank retaining straps back into position with the socket set. Gayen P, Sankarasubramanian S, Ramani VK (2020) Fuel and oxygen. Place the gas tank back onto the floor jack, roll it back under the Expedition and then raise it back into position. Willson D et al (2005) MARS-OZ: a design for a simulated Mars base in the Australian. Tighten the retaining ring in reverse of how you removed it. Lower the new pump down into the tank, making sure to position the fuel level float in such a way that it does not contact the side of the tank. Lift the old fuel pump up and out of the gas tank. You’ll want to turn the ring counterclockwise. The fuel filtet is tucked inside the frame rail under the truck just about under the drivers seat. Wrap the rag around the tip of the screwdriver, place the tip against the fuel pump retaining ring and tap the handle of the screwdriver with the rubber mallet until the retaining ring turns loose. Roll the tank out from under the Expedition and set it on the ground.

Lower the gas tank down using the floor jack, making sure to keep it level. I have a 2005 ford expedition V8 that broke down today, I checked the fuses and found fuse 12 (15amp) blew I replaced it with another and it to blem out checking threw the owners Guide and found another fuse labeled r303 But at the bottom is sayes are not serviceable components see your dealer, both fuses deal with fuel pump relay, fuel pump shut-off switch, fuel pump driver module, fuel pump.

Shop for the best Fuel Pump Driver Module for your 2005 Ford Expedition. Here is a pic of the regulator for a 2005 Expedition w/5.4 liter. 45 2000 Mercury Grand Marquis Fuel Pump Wiring Diagram - Wiring Niche Ideas. Disconnect the fuel filler neck from the tank also using the screwdriver. Fuel pressure regulator is located on the fuel rail attached to the intake manifold. Item location: Scio, New York, United States. The pump is in the top-center of the gas tank. SKI-DOO EFI Fuel Pump 2005-2008 Legend Skandic Expedition SPORT V800 513033120. Lower the tank several inches until you can reach your arm between the tank and the bottom of the Expedition.ĭisconnect the fuel pump wiring and fuel lines from the fuel pump by hand. Instrument cluster.Unbolt the gas tank retaining straps using the socket set.

2005 expedition fuel pump location